Wanderlodge Owners Group  
BuyByeBlueBird.com
Donate

Go Back   Wanderlodge Owners Group > Search Forums

Site Search:
Showing results 1 to 25 of 50
Search took 0.00 seconds.
Search: Posts Made By: Roger Berke
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 11-02-2016
Replies: 14
Views: 8,322
Posted By Roger Berke
You can also order routine service parts, here: ...

You can also order routine service parts, here: Parts - RV Hydronic Heater Repair (http://www.parts.rvhydronicheaterrepair.com/Routine-Maintenance_c3.htm)
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 03-07-2013
Replies: 3
Views: 1,232
Posted By Roger Berke
http://i1311.photobucket.com/albums/s668/RogerBerk...

http://i1311.photobucket.com/albums/s668/RogerBerke/PumpLeak_zps8aff6175.jpg

You probably have a minor leak in the zone pump. There is a "O" ring that gets hard, then leaks coolant.

You have...
Forum: BMC (Bluebird Motor Coach Unique Issues) 10-12-2011
Replies: 10
Views: 3,617
Posted By Roger Berke
Lots and lots of confusion over what type of...

Lots and lots of confusion over what type of coolant is used in different Aqua-Hot models. This is what Aqua-Hot says:
As a general statement, Aqua-Hot models prior to AHE-100-03S and Hydro-Hot...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 09-01-2011
Replies: 4
Views: 1,324
Posted By Roger Berke
Johnny My (very limited) understanding is...

Johnny

My (very limited) understanding is that the new A/C units need a 5 button thermostat.

- Roger Berke -
Forum: Electrical 08-31-2011
Replies: 9
Views: 1,229
Posted By Roger Berke
There is a pretty good drawing below that shows...

There is a pretty good drawing below that shows the electrical system in model 441 series of Aqua-Hot.

The upgrade kit (Aqua-Hot part number ELE-560-024) is also shown below. It replaces the...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 03-22-2011
Replies: 16
Views: 4,197
Posted By Roger Berke
Aqua-Hot Coil Troubleshooting

You can check the coil for proper operation by removing it from the top of the Webasto and applying 12-volts dc to the wires that come out the bottom. Note that the brown wire is the ground and the...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 02-12-2011
Replies: 9
Views: 2,056
Posted By Roger Berke
Turn on the middle zone and give the check valve...

Turn on the middle zone and give the check valve a sharp whack with screwdriver or medium size wrench. It should make the check valve open up.

The middle zone is the (usually) the middle check...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-30-2010
Replies: 10
Views: 2,751
Posted By Roger Berke
We will arrive in Quarzsite January 15th and stay...

We will arrive in Quarzsite January 15th and stay through at least February 6th.

We will join the Southwest Bluebird group from Tuesday, January 25th through Thursday, January 27th. I have been...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-30-2010
Replies: 10
Views: 2,751
Posted By Roger Berke
Randy Thanks for the advertisement. You...

Randy

Thanks for the advertisement. You will find more information about me on my website, which is in my board profile, in the contact section.

- Roger Berke -
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-30-2010
Replies: 10
Views: 2,751
Posted By Roger Berke
RE: Aqua-Hot Quit

You can verify if it is the interior switch or a problem with the Aqua-Hot itself by jumpering across the terminal block as shown in the photo below.

3rd and 4th terminal from the right hand side....
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-28-2010
Replies: 20
Views: 3,272
Posted By Roger Berke
RE: Aqua-Hot in bathroom not working

The relay does control both the pump and the interior fans.

I have never seen a bad relay. If you think you have a bad one, just trade one for one of the other zones. They are all the same.
...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-28-2010
Replies: 20
Views: 3,272
Posted By Roger Berke
RE: Aqua-Hot in bathroom not working

I have never measured the current, however I would expect it to be less than 2 amps. It is only the control box on this circuit. The motor has its own wire and fuse.

- Roger -
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-27-2010
Replies: 20
Views: 3,272
Posted By Roger Berke
Ed This is the 'standard' wiring for your...

Ed

This is the 'standard' wiring for your Aqua-Hot. Yours may be different. Check the middle relay inside the Aqua-Hot. On the left side, there will be two or three wires under one of the...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-27-2010
Replies: 20
Views: 3,272
Posted By Roger Berke
RE: Aqua-Hot in bathroom not working

Rob

The check valves only stick on occasion. If you turn the heat on in your coach about every 30 days, then they probably will not stick again.

If you are having continued problems with a...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-27-2010
Replies: 25
Views: 4,168
Posted By Roger Berke
Aqua-Hot Fuel Pump

The Aqua-Hot uses the Webasto diesel burner that uses proprietary gear driven fuel pump. Looks like the photo below. The fuel pump is driven by a gear that goes through the bottom of the pump. The...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-27-2010
Replies: 20
Views: 3,272
Posted By Roger Berke
RE: Aqua-Hot in bathroom not working

Most of the time when one heat zone is not working the check valve for that zone is stuck shut. Turn on the zone that is not working so that circulation pump starts. Rap on the check valve with...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 02-05-2010
Replies: 14
Views: 8,322
Posted By Roger Berke
RE: Aqua-Hot Popping Sound

Richard

The only relays in your Aqua-Hot are the three relays with the clear plastic cover over them and the relays in the silver box.

The 3 plastic relays control the pumps and the...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 01-14-2010
Replies: 6
Views: 2,240
Posted By Roger Berke
Webasto Working!

Jack

What parts were needed in your Aqua-Hot?

- Roger Berke -
In Quartzsite until end of January
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-21-2009
Replies: 14
Views: 8,322
Posted By Roger Berke
Aqua-Hot Problem

You will find shop manual with troubleshooting guide on the Aqua-Hot website, here: http://www.aqua-hot.com/b2c/ecom/ecomEnduser/default/ArchievedManuals.aspx

I am guessing that you have an...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-21-2009
Replies: 14
Views: 8,322
Posted By Roger Berke
Aqua-Hot Problem

Eddie

This is a portion of a help file that I wrote. It should give you some idea of what is going on.

There is much more information on the group below.

- Roger Berke -
Moderator - Yahoo...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 12-06-2009
Replies: 19
Views: 2,864
Posted By Roger Berke
Aqua-Hot Winterization

Elliot

You can use your Aqua-Hot without any limitations when it is winterized.

- Roger Berke -
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 11-25-2009
Replies: 17
Views: 3,877
Posted By Roger Berke
RE: Aqua-Hot - Winterizing

The only approved method of winterizing your Aqua-Hot is to fill the fresh water system with approved RV winterizing fluid. The procedure is outlined in any of the owners manuals on the Aqua-Hot...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 10-02-2009
Replies: 8
Views: 2,660
Posted By Roger Berke
RE: Aqua-Hot Electric - 2003 LXI

David

Thanks for the lightning fast response.

How is the breaker labeled? There did not appear to be any breaker labeled that could be for the Aqua-Hot. We did not take the time...
Forum: HVAC, Air Conditioners, Aqua Hot, Primus, Webasto, Chassis Heaters, Furnaces and Water Heaters 10-02-2009
Replies: 8
Views: 2,660
Posted By Roger Berke
Aqua-Hot Electric – 2003 LXI

Can anyone tell me where the breaker for the Aqua-Hot electric element is located 2003 LXI? I worked on coach today and we could not find any way to shut off the electric element. There did not...
Forum: General 06-17-2009
Replies: 4
Views: 2,325
Posted By Roger Berke
Aqua-Hot

There is a pretty good discussion of thermostats for the older Aqua-Hot units on this group, here: http://www.wanderlodgeownersgroup.com/forums/showpost.php?p=20152&postcount=25...
Showing results 1 to 25 of 50

 
Forum Jump
Web Search:

All times are GMT -4. The time now is 01:35 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2020, vBulletin Solutions Inc.