Wanderlodge Owners Group  
BuyByeBlueBird.com
Donate

Go Back   Wanderlodge Owners Group > RV Lifestyle > Catastrophes, Fires, Flood, Accidents, etc...

Catastrophes, Fires, Flood, Accidents, etc... Post those photos, videos and articles about the above topics right here of both 'Birds and other RV's to share and compare with the group.

Site Search:
Reply
 
Thread Tools
  #1  
Old 10-13-2017
Stephen Stephen is offline
Senior Member
 
Join Date: Dec 2007
Location: Niagara Falls
Posts: 3,344
Default dometic fridge warning







PAY ATTENTION TO THE HEALTH OF YOUR MOTORHOME AND THE ELECTRICAL SYSTEM YOU ARE PLUGGING IT IN TO




Evidence the circuit board started burning can be seen in right side of the image.
SUN CITY, Ariz. — An RV technician trying to diagnose a problem with an older model RV watched as the unit’s Dometic refrigerator caught fire. His subsequent investigation traced the source to an electrical problem not related to the gas leak commonly cited as the source of refrigerator fires.
The flaw impacts RVs built in the mid-1980s to present with installed Dometic LP gas refrigerators, he told RV Daily Report. It is caused when RV owners attempt to use an adapter to connect a 30-amp, 110-volt RV to a 15-amp, 110-volt power source, whether in a campground or at home.
Adapter plug to allow a 30-amp cord to be used on a 15- or 20-amp power source.

Many RV owners use adapters like the one pictured above, he noted. But, without proper power management, attempting to use an air conditioner and refrigerator together will cause the neutral lug in the plug to get hot.
Once this happens, the Dometic refrigerator control boards will melt down as the current seeks a new neutral connection, the technician explained. That causes the electricity to jump to the earth ground connected to the chassis via the incoming shore earth ground.
“Surprisingly, no fuses of any type blow and the Dometic control boards will catch fire,” he said. “Since they are made of plastic cases, they burn fast and quickly.”
Evidence the circuit board started burning can be seen in right side of the image.

Even without an adapter, an RV park’s well-used shore power pole may have older burned up female plugs from the massive electric use required for things like air conditioning and microwave ovens, he noted.
“Many times we have seen the RV’s male plug’s 30-amp neutral side burned from bad connections caused by the RV not being bonded at the 110-volt box,” he explained. “This recipe for disaster is possible for any RV using the Dometic refrigerator prior to 2000, and possibly beyond.
“However, Dometic did replace the non-warranty board, heating elements and thermistor at my request for the customer,” he explained.
RV Daily Report consulted with two other experienced technicians, who both said it appears the scenario described above is plausible.
One of the technicians, Gary Motley, with Motley RV Repair in Oklahoma City, said he and one of his technicians analyzed the problem in conjunction with a review of Dometic’s home study course.
“Proper voltage and polarity are very important. This refers to 12-volt DC power as well as 115-volt AC power,” said Motley. “The use of a 30-to-15-amp adapter is not good when running an air conditioner.
“Over time, this can cause the connections to overheat and become corroded,” he explained. “When this happens, voltage can be lost over these connections. I have measured this while ‘playing’ in the shop and detected as much as a 9-volt drop.”
The Dometic home study course book specifically points the importance of a good neutral connection and not grounding it through the chassis, Motley noted. The manual also states all connections must be clean and tight.
“This is very important because a loose connection can produce too much heat which can create a fire,” he said.
Technicians looking into situations like this should investigate whether the refrigerator’s heating element was the correct size for that specific model and ensure that the output on the RV’s converter is showing the proper levels, Motley said.
“There are many variables that could cause the problem in this situation that are outside of the control of Dometic,” he explained. “I have never heard of this happening before.”





PAY ATTENTION TO THE HEALTH OF YOUR MOTORHOME AND THE ELECTRICAL SYSTEM YOU ARE PLUGGING IT IN TO
__________________
Have a Great Day
Stephen Birtles
97BMC37

Email stephen@dupreeproducts.com
www.dupreeproducts.com
Telephone 888 668 4288
cell 716 220 1267
Please use email or telephone to contact

Last edited by Stephen; 10-13-2017 at 06:47 PM.
Reply With Quote
  #2  
Old 10-13-2017
Mike Hohnstein's Avatar
Mike Hohnstein Mike Hohnstein is offline
Senior Member
 
Join Date: Jan 2008
Location: NW Milwaukee Metro Area
Posts: 4,262
Default

Yes, got that new 'house' reefer all ready to install in the spring.
__________________
Mike Hohnstein
FMCA 97824
'83FC35rb
Germantown, WI/Myrtle ID
www.AutoTransDesign.com

http://s767.photobucket.com/user/mhohnstein/library/
Reply With Quote
  #3  
Old 10-13-2017
GEEZER GEEZER is offline
Senior Member
 
Join Date: Apr 2013
Location: Azle
Posts: 354
Default House fridge

Quote:
Originally Posted by Mike Hohnstein View Post
Yes, got that new 'house' reefer all ready to install in the spring.
What kind are you going to put in Mike? I am ready to do the same.
__________________
Steve and Vonda Ricketts
Azle, Texas
1983 FC35SB
2003 Jeep Rubicon
Reply With Quote
  #4  
Old 10-14-2017
rshrimp rshrimp is offline
Senior Member
 
Join Date: Apr 2016
Location: Myakka City
Posts: 1,400
Default

Good info! Thanks Stephen!
__________________
Randy and Sonya Shrimplin
FMCA# F457849
Livin' the dream, next door to the Drysdale's in Beverly Hills FL!
2000 LX40 ME "Angry Bird!"
Body# 129047
RShrimp@Yahoo.com
Reply With Quote
Reply

Bookmarks

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
1986 pt 36 Dometic fridge jsreen06 Vehicle Issues 5 07-26-2017 09:44 PM
Dometic Fridge DOA near Yellowstone JAMULPI Vehicle Issues 6 07-09-2014 09:04 AM
Dometic Fridge does not like 120 dackerman General 9 06-29-2013 06:40 PM
Dometic fridge for sale Rose Mary Parts and Other Items For Sale 3 11-11-2012 04:45 PM
CL - dometic fridge near sou cen ohio SGallaty Craigs List, Ebay, Coaches and other Finds 4 07-20-2010 09:55 PM

Web Search:

All times are GMT -4. The time now is 10:10 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2019, vBulletin Solutions Inc.